致密砂岩巷道模型试件动态起裂及止裂全过程分析

周磊; 朱哲明; 王蒙; 周昌林; 董玉清; 应鹏

doi:10.11883/bzycj-2018-0073

致密砂岩巷道模型试件动态起裂及止裂全过程分析

doi: 10.11883/bzycj-2018-0073

四川大学建筑与环境学院深地科学与工程教育部重点实验室，四川成都 610065

基金项目: 国家自然科学基金资助项目（11672194）；四川省科技计划项目（2018JZ0036）；四川省安全监管局安全生产科技项目（aj20170515161307）

详细信息

作者简介:
周　磊（1990－　），男，博士，现任助理研究员，zhouleittkx@126.com

通讯作者:
朱哲明（1965－　），男，教授，博士，博士生导师，zhemingzhu@hotmail.com

中图分类号: O389
计量
- 文章访问数: 5188
- HTML全文浏览量: 1493
- PDF下载量: 45
- 被引次数: 0
出版历程
- 收稿日期: 2018-03-09
- 修回日期: 2018-05-09
- 网络出版日期: 2019-08-25
- 刊出日期: 2019-09-01

Analysis on whole dynamical fracture process of tight sandstone tunnel model under impact loading

MOE Key Laboratory of Deep Underground Science and Engineering, College of Architecture and Environment, Sichuan University, Chengdu 610065, China

摘要

摘要: 为了开展在不同冲击载荷作用下巷道围岩内裂纹的起裂、扩展及止裂等问题，以可调速冲击试验机进行动态加载试验，采用致密青砂岩制作裂纹巷道模型试件，并利用裂纹扩展计分别记录了动态起裂、扩展、止裂等时刻，对裂纹扩展速度的变化规律进行分析；随后采用AUTODYN有限差分法软件进行相应的数值模拟，数值模拟得到的裂纹扩展路径与试验结果基本一致。经过两者对比分析可知：随着冲击载荷作用的增加，裂纹平均扩展速度逐渐增大，随后趋于稳定值；预制裂纹的起裂时间随着冲击速度载荷的增加而逐渐降低，并在稳定值上下波动；随着冲击速度载荷的增加，裂纹扩展路径过程中的止裂时段逐渐变短。
- 巷道 /
- 冲击载荷 /
- 裂纹扩展速度 /
- 起裂时间 /
- 止裂时间
Abstract: In order to investigate the properties of crack fracture time, propagation speed and arrest period in the surrounding rock of tunnel under different impact loading speed, the dynamic tests were performed by self-developed adjustable speed drop weight impact test system, and the tight green sandstone was selected to make the cracked tunnel specimens. A crack propagation gauge (CPG) was applied to measure dynamic initiation time, propagation speeds and arrest time, respectively. The properties of crack propagation velocity, crack fracture time and crack arrest period were discussed and analyzed. The corresponding numerical simulation was carried out by AUTODYN code, and the simulation results showed that the crack propagation speeds and crack fracture time generally agree with the experimental results, and crack arrest period also was calculated. The results show that crack propagation speeds increase with impact loading speed, but as the impact loading speed is larger than a certain value, the crack speeds tend toward a stable value; Crack fracture time decreases with the increase of impact loading speed, and as the loading rate is larger than a certain value, it tends toward a stable value; With the increase of the impact loading speed, the crack arrest period in the crack propagation path gradually decreases.
- tunnel /
- impact loading /
- crack propagation speeds /
- crack fracture time /
- crack arrest time

HTML全文

图 1 巷道模型示意图(单位：mm)

Figure 1. Sketch map of tunnel model (unit: mm)

下载: 全尺寸图片幻灯片

图 2 数值模型网格单元示意图

Figure 2. Sketch map of numerical model mesh unit

下载: 全尺寸图片幻灯片

图 3 数值模拟结果分析

Figure 3. Numerical simulation results

下载: 全尺寸图片幻灯片

图 4 高斯点的应力时程曲线

Figure 4. Normal stress time curves of Gauss point

下载: 全尺寸图片幻灯片

图 5 裂纹扩展特性曲线

Figure 5. Curves of crack propagation properties

下载: 全尺寸图片幻灯片

图 6 裂纹平均扩展速度与起裂时间趋势线

Figure 6. The trendline of crack average propagation velocity and initiation time

下载: 全尺寸图片幻灯片

图 7 裂纹止裂区间趋势线

Figure 7. The trendline of crack arrest period

下载: 全尺寸图片幻灯片

图 8 试验装置

Figure 8. Test device

下载: 全尺寸图片幻灯片

图 9 冲载载荷

Figure 9. Impact loading force

下载: 全尺寸图片幻灯片

图 10 CPG示意图

Figure 10. Sketch map of CPG

下载: 全尺寸图片幻灯片

图 11 CPG 测试数据分析

Figure 11. Analysis of CPG test data

下载: 全尺寸图片幻灯片

图 12 试验测试裂纹平均扩展速度与起裂时间结果值

Figure 12. Test results of crack average propagation speed and initiation time

下载: 全尺寸图片幻灯片

表 1 砂岩及杆件材料参数

Table 1. Material parameters of sandstone and LY12CZ

材料	ρ/(kg∙m⁻³)	σ_c/(MPa)	σ_t/(MPa)	K_IC/(MPa∙m^1/2)	E_d/(GPa)	ν_d	c_d/(m·s⁻¹)	c_s/(m·s⁻¹)	c_R/(m·s⁻¹)
LY12CZ	2850				71.7	0.3	5006
砂岩	2265	22.08	1.08	0.468	13.58	0.164	2563	1639	1479.9
注：ρ为密度，σ_c为单轴抗压强度，σ_t为单轴抗拉强度，K_IC为静态断裂韧度，E_d为弹性模量，ν_d为泊松比，c_d为纵波波速，c_s为横波波速，c_R为瑞雷　　波波速.

下载: 导出CSV

表 2 CPG测试结果

Table 2. CPG test results

试件编号	v/(m∙s⁻¹)	t_i/μs	v_a/(m∙s⁻¹)	试件编号	v/(m∙s⁻¹)	t_i/μs	v_a/(m∙s⁻¹)
1	1.939	315	177.957	9	5.903	277	598.180
2	2.435	307	224.744	10	6.398	274	613.668
3	2.930	305	239.419	11	6.893	265	628.571
4	3.425	282	301.829	12	7.389	261	647.059
5	3.921	275	443.548	13	7.884	255	659.176
6	4.578	279	458.881	14	8.380	262	672.780
7	4.912	274	486.189	15	8.683	257	674.386
8	5.407	266	574.912

下载: 导出CSV

参考文献(35)

[1]	李地元, 成腾蛟, 周韬, 等. 冲击载荷作用下含孔洞大理岩动态力学破坏特性试验研究 [J]. 岩石力学与工程学报, 2015, 34(2): 249–260. LI Diyuan, CHENG Tengjiao, ZHOU Tao, et al. Experimental study of the dynamic strength and fracturing characteristics of marble specimens with a single hole under impact loading [J]. Chinese Journal of Rock Mechanics and Engineering, 2015, 34(2): 249–260.
[2]	杨井瑞, 张财贵, 周妍, 等. 用CSTBD试样确定砂岩的动态起裂和扩展韧度 [J]. 爆炸与冲击, 2014, 34(3): 264–271. DOI: 10.11883/1001-1455(2014)03-0264-08. YANG Jingrui, ZHANG Caigui, ZHOU Yan, et al. Determination of dynamic initiation toughness and propagation toughness of sandstone using CSTBD specimens [J]. Explosion and Shock Waves, 2014, 34(3): 264–271. DOI: 10.11883/1001-1455(2014)03-0264-08.
[3]	潘峰, 党发宁, 焦凯, 等. 冲击荷载作用下不均匀脆性材料动态弯拉强度提高机制研究 [J]. 岩石力学与工程学报, 2015, 34(S2): 3948–3955. PAN Feng, DANG Faning, JIAO Kai., et al Mechanism on enhancement of dynamic flexural tensile strength for nonuniform brittle materials under impact loading [J]. Chinese Journal of Rock Mechanics and Engineering, 2015, 34(S2): 3948–3955.
[4]	李地元, 邱加冬, 李夕兵. 冲击载荷作用下层状砂岩动态拉压力学特性研究 [J]. 岩石力学与工程学报, 2015(10): 2091–2097. LI Diyuan, QIU Jiadong, LI Xibing. Experimental study on dynamic tensile and compressive properties of bedding sandstone under impact loading [J]. Chinese Journal of Rock Mechanics and Engineering, 2015(10): 2091–2097.
[5]	LI J C, LI N N, LI H B, et al. An SHPB test study on wave propagation across rock masses with different contact area ratios of joint [J]. International Journal of Impact Engineering, 2017, 105: 109–116. DOI: 10.1016/j.ijimpeng.2016.12.011.
[6]	胡柳青, 李夕兵, 龚声武. 冲击载荷作用下裂纹动态响应的数值模拟 [J]. 爆炸与冲击, 2006, 26(3): 214–221. HU Liuqing, LI Xibing, GONG Shengwu. Simulation on dynamic response of crack subjected to impact loading [J]. Explosion and Shock Waves, 2006, 26(3): 214–221.
[7]	WANG M, ZHU Z, DONG Y, et al. Study of mixed-mode I/Ⅱ fractures using single cleavage semicircle compression specimens under impacting loads [J]. Engineering Fracture Mechanics, 2017, 177: 33–44. DOI: 10.1016/j.engfracmech.2017.03.042.
[8]	WANG Q, FENG F, NI M, et al. Measurement of mode I and mode Ⅱ rock dynamic fracture toughness with cracked straight through flattened Brazilian disc impacted by split Hopkinson pressure bar [J]. Engineering Fracture Mechanics, 2011, 78(12): 2455–2469. DOI: 10.1016/j.engfracmech.2011.06.004.
[9]	WANG Q, XING L. Determination of fracture toughness K IC by using the flattened Brazilian disk specimen for rocks [J]. Engineering Fracture Mechanics, 1999, 64(2): 193–201. DOI: 10.1016/S0013-7944(99)00065-X.
[10]	WANG Q, YANG J, ZHANG C, et al. Sequential determination of dynamic initiation and propagation toughness of rock using an experimental-numerical-analytical method [J]. Engineering Fracture Mechanics, 2015, 141: 78–94. DOI: 10.1016/j.engfracmech.2015.04.025.
[11]	ZHANG Q B, ZHAO J. Effect of loading rate on fracture toughness and failure micromechanisms in marble [J]. Engineering Fracture Mechanics, 2013, 102(2): 288–309.
[12]	ZHANG Q B, ZHAO J. Determination of mechanical properties and full-field strain measurements of rock material under dynamic loads [J]. International Journal of Rock Mechanics and Mining Sciences, 2013, 60(8): 423–439.
[13]	宋义敏, 何爱军, 王泽军, 等. 冲击载荷作用下岩石动态断裂试验研究 [J]. 岩土力学, 2015, 36(4): 965–970. SONG Yiming, HE Aijun, WANG Zhejun, et al. Experiment study of the dynamic fractures of rock under impact loading [J]. Rock and Soil Mechanics, 2015, 36(4): 965–970.
[14]	宋义敏, 杨小彬, 金璐, 等. 冲击载荷作用下岩石I型裂纹动态断裂试验研究 [J]. 振动与冲击, 2014, 33(11): 49–53. SONG Yiming, YANG Xiaobin, JIN Lu, et al. Dynamic fracture test for rock I-type crack under impact load [J]. Journal of Vibration and Shock, 2014, 33(11): 49–53.
[15]	宋义敏, 杨小彬, 杨晟萱, 等. 冲击载荷下岩石裂纹动态断裂参数研究 [J]. 采矿与安全工程学报, 2015, 32(5): 834–839. SONG Yimin, YANG Xiaobin, YANG Shenxuan, et al. The research of rock dynamic fracture parameter under the action of impact load [J]. Journal of Mining and Safety Engineering, 2015, 32(5): 834–839.
[16]	潘一山, 吕祥锋, 李忠华, 等. 高速冲击载荷作用下巷道动态破坏过程试验研究 [J]. 岩土力学, 2011, 32(5): 1281–1286. DOI: 10.3969/j.issn.1000-7598.2011.05.001. PAN Yishan, LÜ Xiangfeng, LI Zhonghua, et al. Experimental study of dynamic failure process of roadway under high velocity impact loading [J]. Rock and Soil Mechanics, 2011, 32(5): 1281–1286. DOI: 10.3969/j.issn.1000-7598.2011.05.001.
[17]	郭东明, 刘康, 胡久羡, 等. 爆生气体对邻近硐室背爆侧预制裂纹影响机理 [J]. 煤炭学报, 2016, 41(1): 265–270. GUO Dongming, LIU Kang, HU Jiuxian, et al. Experimental study on the effect mechanism of the explosion gas on the precrack in the back-blasting of adjacent tunnel [J]. Journal of China Coal Society, 2016, 41(1): 265–270.
[18]	郭东明, 刘康, 杨仁树, 等. 爆破对邻近巷道背爆侧倾斜裂纹影响实验研究 [J]. 采矿与安全工程学报, 2015, 32(1): 99–104. GUO Dongming, LIU Kang, YANG Renshu, et al. Experimental research on the influence of blasting on the inclined crack in the back-blasting side of nearby roadway [J]. Journal of Mining and Safety Engineering, 2015, 32(1): 99–104.
[19]	郭东明, 刘康, 杨仁树, 等. 动静荷载对邻近巷道裂纹缺陷扰动的模拟实验 [J]. 爆炸与冲击, 2016, 36(3): 297–304. DOI: 10.11883/1001-1455(2016)03-0297-08. GUO Dongming, LIU Kang, YANG Renshu, et al. Simulated experiment of disturbance effect on crack defects of adjacent tunnel under dynamic and static load [J]. Explosion and Shock Waves, 2016, 36(3): 297–304. DOI: 10.11883/1001-1455(2016)03-0297-08.
[20]	李地元, 韩震宇, 孙小磊, 等. 含预制裂隙大理岩SHPB动态力学破坏特性试验研究 [J]. 岩石力学与工程学报, 2017, 36(12): 2872–2883. LI Diyuan, HAN Zhenyu, SUN Xiaolei, et al. Dynamic mechanical failure characteristics of marble withartificial flawsunder shpb tests [J]. Chinese Journal of Rock Mechanics and Engineering, 2017, 36(12): 2872–2883.
[21]	王登科, 刘淑敏, 魏建平, 等. 冲击载荷作用下煤的破坏特性试验研究 [J]. 采矿与安全工程学报, 2017, 34(3): 594–600. WANG Dengke, LIU Shumin, WEI Jianping, et al. The failure characteristics of coal under impact load in laboratory [J]. Journal of Mining and Safety Engineering, 2017, 34(3): 594–600.
[22]	袁璞, 马瑞秋. 不同含水状态下煤矿砂岩SHPB试验与分析 [J]. 岩石力学与工程学报, 2015, 34(S1): 2888–2893. YUAN Pu, MA Ruiqiu. Split Hopkinson pressure bar tests and analysis of coalmine sandstone with various moisture contents [J]. Chinese Journal of Rock Mechanics and Engineering, 2015, 34(S1): 2888–2893.
[23]	赵毅鑫, 肖汉, 黄亚琼. 霍普金森杆冲击加载煤样巴西圆盘劈裂试验研究 [J]. 煤炭学报, 2014, 39(2): 286–291. ZHAO Yixin, XIAO Han, HUANG Yaqiong. Dynamic split tensile test of Brazilian disc of coal with split Hopkinson pressure bar loading [J]. Journal of China Coal Society, 2014, 39(2): 286–291.
[24]	SAKSALA T, HOKKA M, KUOKKALA V T, et al. Numerical modeling and experimentation of dynamic Brazilian disc test on Kuru granite [J]. International Journal of Rock Mechanics and Mining Sciences, 2013, 59(8): 128–138.
[25]	周磊, 朱哲明, 董玉清, 等. 中低速冲击载荷下巷道内裂纹的动态响应 [J]. 岩石力学与工程学报, 2017, 36(6): 1363–1372. ZHOU Lei, ZHU Zheming, DONG Yuqing, et al. Dynamic response of cracks in tunnels under impact loading of medium-low speed [J]. Chinese Journal of Rock Mechanics and Engineering, 2017, 36(6): 1363–1372.
[26]	周磊, 朱哲明, 刘邦. 隧道周边不同位置径向裂纹对隧道围岩稳定性影响规律的研究 [J]. 岩土工程学报, 2016, 38(7): 1230–1237. DOI: 10.11779/CJGE201607009. ZHOU Lei, ZHU Zheming, LIU Bang. Influence of radial cracks on stability of surrounding rocks at different locations around tunnel [J]. Chinese Journal of Geotechnical Engineering, 2016, 38(7): 1230–1237. DOI: 10.11779/CJGE201607009.
[27]	周磊, 朱哲明, 刘邦. 裂纹对直墙拱形隧道围岩损伤破坏模式的影响规律研究 [J]. 岩土力学, 2017, 38(12): 3688–3697. ZHOU Lei, ZHU Zheming, LIU Bang. Influence of cracks on surrounding rock damage-failure mode of straight wall arch tunnel [J]. Rock and Soil Mechanics, 2017, 38(12): 3688–3697.
[28]	ZHOU L, ZHU Z, WANG M, et al. Dynamic propagation behavior of cracks emanating from tunnel edges under impact loads [J]. Soil Dynamic and Earthquake Engineering, 2018, 105: 119–126. DOI: 10.1016/j.soildyn.2017.12.012.
[29]	ZHU Z. Numerical prediction of crater blasting and bench blasting [J]. International Journal of Rock Mechanics and Mining Sciences, 2009, 46(6): 1088–1096. DOI: 10.1016/j.ijrmms.2009.05.009.
[30]	ZHU Z, MOHANTY B, XIE H. Numerical investigation of blasting-induced crack initiation and propagation in rocks [J]. International Journal of Rock Mechanics and Mining Sciences, 2007, 44(3): 412–424. DOI: 10.1016/j.ijrmms.2006.09.002.
[31]	ZHU Z, XIE H, MOHANTY B. Numerical investigation of blasting-induced damage in cylindrical rocks [J]. International Journal of Rock Mechanics and Mining Sciences, 2008, 45(2): 111–121. DOI: 10.1016/j.ijrmms.2007.04.012.
[32]	LI M, ZHU Z, LIU R, et al. Study of the effect of empty holes on propagating cracks under blasting loads [J]. International Journal of Rock Mechanics and Mining Sciences, 2018, 103: 186–194. DOI: 10.1016/j.ijrmms.2018.01.043.
[33]	唐志平, 王礼立. SHPB实验的电脑化数据处理系统 [J]. 爆炸与冲击, 1986, 6(4): 34–41. TANG Zhiping, WANG Lili. A computerized system of data processing used in SHPB experiments [J]. Explosion and Shock Waves, 1986, 6(4): 34–41.
[34]	刘德顺, 李夕兵. 冲击机械系统动力学. 北京: 科学出版社, 1999.
[35]	ZHANG Q B, ZHAO J. A review of dynamic experimental techniques and mechanical behavior of rock materials [J]. Rock Mechanics and Rock Engineering, 2014, 47(4): 1411–1478. DOI: 10.1007/s00603-013-0463-y.