An experimental study of anti-penetration performance of concrete-filled steel tube with honeycomb structure
-
摘要: 为了研究蜂窝钢管混凝土的抗侵彻性能，采用125 mm口径滑膛炮开展了蜂窝钢管混凝土靶侵彻实验共6发，获得了不同工况时靶板破坏形态及侵深数据，分析了蜂窝钢管混凝土的典型破坏形式，对比了不同弹靶尺寸因数时靶板破坏形式的区别以及着靶点和钢管壁厚对蜂窝钢管混凝土抗侵彻能力的影响。同时，对7组不同壁厚的六边形钢管混凝土和3组六边形无钢管混凝土柱进行了单轴压缩实验，研究了不同壁厚时六边形钢管对核心混凝土强度及延性的增强效应，拟合了核心混凝土强度增强因数同围箍因数的关系，并改进普通混凝土侵深的经验公式，得到了适用于蜂窝钢管混凝土的最大侵深计算公式。结果表明：钢管壁厚是影响侵深的重要因素，壁厚越大，侵深越小；着靶点位置对侵深的影响较复杂，具有离散性；着靶点位置对靶体表面破坏形式影响较大；钢管可以有效增加核心混凝土的强度和延性；改进后的侵深计算公式可以预测弹体对蜂窝钢管混凝土靶的最大侵深。
-
关键词:
- 抗侵彻性能 /
- 125 mm口径滑膛炮 /
- 蜂窝钢管混凝土 /
- 强度增强效应 /
- 侵彻深度
Abstract: In order to study the anti-penetration performance of concrete-filled steel tube (CFST) with honeycomb structure, six experiments on anti-penetration of the CFST with honeycomb structure were conducted by using a 125-mm smooth bore gun. The failure pattern and penetration depth of the targets under different working conditions were measured, and the typical failure modes of the CFST with honeycomb structure were analyzed. The differences of the failure pattern of the targets under different target-to-projectile size ratios were compared, while the influences of the impact point and steel tube wall thickness on the anti-penetration performance of the CFST with honeycomb structure were explored. Uniaxial compression tests on seven groups of hexagonal concrete-filled steel tube columns with different wall thicknesses and three groups of hexagonal concrete columns were carried out. The enhancement effects of the hexagonal steel tube on the strength and ductility of the core concrete under different wall thicknesses were studied, and the relationship between the strength enhancement coefficient of the core concrete and the hoop coefficient was obtained by data fitting. By refining the empirical formula for calculating the penetration depth of ordinary concrete, the formula for calculating the maximum penetration depth of the CFST targets with honeycomb structure was given. The results show that the wall thickness is an important factor that affects penetration depth, that is, the greater the wall thickness, the smaller the penetration depth. The locations of impact points have a great influence on the failure pattern of the target surface, but the influences of the locations of impact points on the penetration depth are complex. The existence of the steel tube can effectively increase the strength and ductility of the core concrete. The refined penetration depth formula can predict the maximum penetration depths of the projectiles to the CFST targets with honeycomb structure. -
图 6 交点着靶时弹体偏转痕迹和钢管剪切破坏
Figure 6. Deflection marks of projectile and shear failures of steel tube wall under intersecting point impact
图 8 实验及按初速换算后的侵彻深度
Figure 8. Experimental and converted penetration depths based on initial velocity
图 15 核心混凝土强度增强因数与围箍因数的关系
Figure 15. The relationship between the strength enhancement factor of core concrete and the hoop factor
表 1 侵彻实验结果
Table 1. Results of the penetration experiments
靶体 钢管 壁厚/mm 着靶点 初速/（m·s−1） 弹重/kg 侵深/mm 开坑尺寸/mm2 F-1 有 5 中心 352 20.60 478 320×410 F-2 有 5 交点 274 20.62 290 300×420 F-3 有 5 交点 271 22.40 294 290×370 E-1 有 8 中心 274 20.57 280 290×300 E-2 有 8 交点 307 20.61 324 290×290 E-3 有 8 中心 317 22.42 357 350×400 S-1 无 — — 271 22.41 310 1150×1170 
下载: 导出CSV
表 2 按初速换算后的侵彻深度
Table 2. Penetration depths converted by initial velocity
靶体 钢管 壁厚/mm 着靶点 初速/（m·s−1） 换算初速/（m·s−1） 侵深/mm 换算侵深/mm F-1 有 5 中心 352 274 478 370 E-1 有 8 中心 274 307 280 313
下载: 导出CSV
表 3 核心混凝土的强度增强因数
Table 3. Strength enhancement coefficients of core concretes
试件 钢管 b/mm t/mm δ P/MN ${\sigma _{\text{r}}}$/MPa fc*/MPa k 1 无 — — 0 0.964 0 57.9 1 2 无 — — 0 1.035 0 62.0 1 3 无 — — 0 0.904 0 54.1 1 4 有 80 5 0.52 2.361 13.8 104.9 1.81 5 有 80 5 0.52 2.366 13.9 105.2 1.82 6 有 80 5 0.52 2.354 13.6 104.2 1.79 7 有 80 8 0.83 3.034 17.3 116.7 2.01 8 有 80 8 0.83 2.962 15.5 110.6 1.91 9 有 80 8 0.83 3.000 16.5 114.0 1.96
下载: 导出CSV
表 4 实验和计算的侵彻深度
Table 4. Experimental and computational penetration depths
靶体 钢管 壁厚/mm 着靶点 初速/（m·s−1） 实验侵深/mm 计算侵深/mm 误差/% F-1 有 5 中心 352 478 400 16.31 E-1 有 8 中心 274 280 290 3.57 E-3 有 8 中心 317 357 364 1.96
下载: 导出CSV
-
[1] 党爱国, 李晓军. 国外钻地武器发展回顾及展望 [J]. 飞航导弹, 2014(6): 35–39. DOI: 10.16338/j.issn.1009-1319.2014.06.008. [2] 纪冲, 龙源, 万文乾, 等. 钢纤维混凝土抗侵彻与贯穿特性的实验研究 [J]. 爆炸与冲击, 2008, 28(2): 178–185. DOI: 10.11883/1001-1455(2008)02-0178-08.JI C, LONG Y, WAN W Q, et al. On anti-penetration and anti-perforation characteristics of high-strength steel fiber-reinforced concrete [J]. Explosion and Shock Waves, 2008, 28(2): 178–185. DOI: 10.11883/1001-1455(2008)02-0178-08. [3] SOVJÁK R, VAVŘINÍK T, MÁCA P, et al. Experimental investigation of ultra-high performance fiber reinforced concrete slabs subjected to deformable projectile impact [J]. Procedia Engineering, 2013, 65: 120–125. DOI: 10.1016/j.proeng.2013.09.021. [4] LAI J Z, GUO X J, ZHU Y Y. Repeated penetration and different depth explosion of ultra-high performance concrete [J]. International Journal of Impact Engineering, 2015, 84: 1–12. DOI: 10.1016/j.ijimpeng.2015.05.006. [5] 石少卿, 黄翔宇, 刘颖芳, 等. 多边形钢管混凝土短构件在防护工程中的应用 [J]. 混凝土, 2005(2): 95–98. DOI: 10.3969/j.issn.1002-3550.2005.02.027.SI S Q, HUANG X Y, LIU Y F, et al. Application of polygonal short steel tube filled with concrete on the defense work [J]. Concrete, 2005(2): 95–98. DOI: 10.3969/j.issn.1002-3550.2005.02.027. [6] MU Z C, DANCYGIER A N, ZHANG W, et al. Revisiting the dynamic compressive behavior of concrete-like materials [J]. International Journal of Impact Engineering, 2012, 49: 91–102. DOI: 10.1016/j.ijimpeng.2012.05.002. [7] 甄明. 有限空腔膨胀理论及约束混凝土抗侵彻机理研究 [D]. 长沙: 国防科学技术大学, 2013.ZHEN M. Investigation of finite cavity expansion and the mechanism of confined concrete against penetration [D]. Changsha, Hunan, China: National University of Defense Technology, 2013. [8] 甄明, 蒋志刚, 万帆, 等. 钢管约束混凝土抗侵彻性能试验 [J]. 国防科技大学学报, 2015, 37(3): 121–127. DOI: 10.11887/j.cn.201503020.ZHEN M, JIANG Z G, WAN F, et al. Steeltube confined concrete targets penetration experiments [J]. Journal of National University of Defense Technology, 2015, 37(3): 121–127. DOI: 10.11887/j.cn.201503020. [9] 蒙朝美, 宋殿义, 蒋志刚, 等. 多边形钢管约束混凝土靶抗侵彻性能试验研究 [J]. 振动与冲击, 2018, 37(13): 14–19. DOI: 10.13465/j.cnki.jvs.2018.13.003.MENG C M, SONG D Y, JIANG Z G, et al. Tests for anti-penetration performance of polygonal steel tube-confined concrete targets [J]. Journal of Vibration and Shock, 2018, 37(13): 14–19. DOI: 10.13465/j.cnki.jvs.2018.13.003. [10] 詹昊雯. 钢管约束混凝土遮弹结构抗射弹侵彻效应研究 [D]. 长沙: 国防科技大学, 2017.ZHAN H W. Investigation on the anti-penetration effects of steel-tube-confined concrete shield structures [D]. Changsha, Hunan, China: National University of Defense Technology, 2017. [11] 王起帆, 石少卿, 王征, 等. 蜂窝遮弹层抗弹丸侵彻实验研究 [J]. 爆炸与冲击, 2016, 36(2): 253–258. DOI: 10.11883/1001-1455(2016)02-0253-06.WANG Q F, SHI S Q, WANG Z, et al. Experimental study on penetration-resistance characteristics of honeycomb shelter [J]. Explosion and Shock Waves, 2016, 36(2): 253–258. DOI: 10.11883/1001-1455(2016)02-0253-06. [12] BAŽANT Z P, PLANAS J. Fracture and size effect in concrete and other quasibrittle materials [M]. Boca Raton: CRC Press, 1998. [13] ISSA Mohsen A, ISSA Mahmoud A, ISLAM M S, et al. Size effects in concrete fracture (Ⅱ): analysis of test results [J]. International Journal of Fracture, 2000, 102(1): 25–42. DOI: 10.1023/A:1007677705861. [14] ISSA Mohsen A, ISSA Mahmoud A, ISLAM M S, et al. Size effects in concrete fracture (Ⅰ): experimental setup and observations [J]. International Journal of Fracture, 2000, 102(1): 1–24. DOI: 10.1023/A:1007533218153. [15] VAN VLIET M R A, VAN MIER J G M. Experimental investigation of size effect in concrete and sandstone under uniaxial tension [J]. Engineering Fracture Mechanics, 2000, 65(2/3): 165–188. DOI: 10.1016/S0013-7944(99)00114-9. [16] DING F X, LI Z, CHENG S S, et al. Composite action of hexagonal concrete-filled steel tubular stub columns under axial loading [J]. Thin-Walled Structures, 2016, 107: 502–513. DOI: 10.1016/j.tws.2016.07.005. [17] 金栋梁, 何翔, 刘瑞朝, 等. 岩石侵彻深度经验公式 [C] // 第五届全国工程结构安全防护学术会议. 南京: 中国力学学会, 2005. [18] 何翔, 刘瑞朝, 吴飚, 等. 现场岩体侵彻试验研究及侵彻深度经验公式的提出 [C] // 中国软岩工程与深部灾害控制研究进展: 第四届深部岩体力学与工程灾害控制学术研讨会暨中国矿业大学(北京)百年校庆学术会议论文集. 北京: 中国岩石力学与工程学会, 2009. -
点击查看大图
图(15) / 表(4)
计量
- 文章访问数: 480
- HTML全文浏览量: 100
- PDF下载量: 112
- 被引次数: 0