Spectral analysis on electrical explosion of copper wire

Jin Yong; Li Bao -ming

doi:10.11883/1001-1455(2014)02-0252-05

Volume 34 Issue 2

May 2014

Turn off MathJax

Article Contents

Abstract

References

Article Navigation > Explosion And Shock Waves > 2014 > 34(2): 252-256

Jin Yong, Li Bao -ming. Spectral analysis on electrical explosion of copper wire[J]. Explosion And Shock Waves, 2014, 34(2): 252-256. doi: 10.11883/1001-1455(2014)02-0252-05

Citation:

Jin Yong, Li Bao -ming. Spectral analysis on electrical explosion of copper wire[J]. Explosion And Shock Waves, 2014, 34(2): 252-256. doi: 10.11883/1001-1455(2014)02-0252-05

Jin Yong, Li Bao -ming. Spectral analysis on electrical explosion of copper wire[J]. Explosion And Shock Waves, 2014, 34(2): 252-256. doi: 10.11883/1001-1455(2014)02-0252-05

Citation:

Jin Yong, Li Bao -ming. Spectral analysis on electrical explosion of copper wire[J]. Explosion And Shock Waves, 2014, 34(2): 252-256. doi: 10.11883/1001-1455(2014)02-0252-05

PDF( 1539 KB)

Spectral analysis on electrical explosion of copper wire

doi: 10.11883/1001-1455(2014)02-0252-05

Jin Yong^,,
Li Bao -ming

National Key Laboratory of Transient Physics, Nanjing University of Science and Technology, Nanjing 210094, Jiangsu, China

Funds: Supported by the National High -tech R & D Program (863Program) (2012AA8091201)

More Information

Corresponding author: Jin Yong, kingdeyu@163.com
Received Date: 2012-09-03
Rev Recd Date: 2013-03-26
Publish Date: 2014-03-25

Abstract

Abstract

A pulse forming network (PFN)discharge module and a spectroscopy system were employed to discuss the electrical explosion of copper wire.The plasma emission spectra were obtained in the wavelength range of 400-500nm by an Andor SR750spectrograph.Based on the thermodynamic equilibrium theory, the arc plasma excitation temperature was calculated by the relative line intensities.And the variation characteristic of the excitation temperature was discussed.The results show that the steady -state plasma excitation temperature by the exploding copper wire is approximately 5400K.The excitation temperature changes obviously in the prophase of the pulse discharge and it is relatively stable at the later stage of the pulse discharge.The excitation temperature difference during the whole pulse time is about 800K.
- mechanics of explosion,
- excitation temperature,
- relative line intensities,
- copper wire,
- electrical explosion,
- arc plasma

FullText(HTML)

References(16)

References

[1]	Dyvik J, Herbig J, Appleton R, et al. Recent activities in electrothermal chemical launcher technologies at BAE systems[J]. IEEE Transactions on Magnetics, 2007, 43(1): 303-307. doi: 10.1109/TMAG.2006.887707
[2]	Kim K. Time-dependent one-dimensional modeling of pulsed plasma discharge in a capillary plasma device[J]. IEEE Transactions on Plasma Science, 2003, 31(4): 729-735. doi: 10.1109/TPS.2003.815472
[3]	Christou C. Temporally resolved visible and UV spectroscopy of exploding wires[J]. IEEE Transactions on Magnetics, 1995, 31(1): 689-691. doi: 10.1109/20.364610
[4]	王广海, 李国新, 焦清介, 等.光谱辐射测量金属薄膜桥电爆炸温度[J].含能材料, 2009, 17(5): 616-618. doi: 10.3969/j.issn.1006-9941.2009.05.027 Wang Guang-hai, Li Guo-xin, Jiao qing-jie, et al. Electrical explosion temperature of metal thin film bridge measured by spectrum radiation method[J]. Chinese Journal of Energetic Materials, 2009, 17(5): 616-618. doi: 10.3969/j.issn.1006-9941.2009.05.027
[5]	陈林, 周之奎, 孙承纬.电热化学发射中等离子体发生器放电特性的实验研究[J].爆炸与冲击, 1997, 17(4): 375-381. http://www.bzycj.cn/CN/Y1997/V17/I4/375 Chen Lin, Zhou Zhi-kui, Sun Cheng-wei. Experimental studies on discharge characteristics of plasma generator in electrothermal-chemical launchers[J]. Explosion and Shock Waves, 1997, 17(4): 375-381. http://www.bzycj.cn/CN/Y1997/V17/I4/375
[6]	伍俊英, 冯长根, 陈朗, 等.金属电爆炸等离子体辐射温度测量[J].战术导弹技术, 2006, 9(5): 31-33. doi: 10.3969/j.issn.1009-1300.2006.05.007 Wu Jun-ying, Feng Chang-gen, Chen Lang, et al. Plasma radiation temperature measurement of metal explosion[J]. Tactical Missile Technology, 2006, 9(5): 31-33. doi: 10.3969/j.issn.1009-1300.2006.05.007
[7]	林兆祥, 李小银, 程学武, 等.激光大气等离子体时间演化特性的光谱研究[J].光谱学与光谱分析, 2003, 23(3): 421-425. doi: 10.3321/j.issn:1000-0593.2003.03.002 Lin Zhao-xiang, Li Xiao-yin, Cheng Xue-wu, et al. Spectroscopic study on the time evolution behaviors of the laserinduced air plasma[J]. Spectroscopy and Spectral Analysis, 2003, 23(3): 421-425. doi: 10.3321/j.issn:1000-0593.2003.03.002
[8]	任庆磊, 林麒.低温等离子体的光谱测量研究[J].光谱实验室, 2007, 24(5): 839-843. doi: 10.3969/j.issn.1004-8138.2007.05.021 Ren Qing-Lei, Lin Qi. Study on spectral measurement of low temperature plasma[J]. Chinese Journal of Spectroscopy Laboratory, 2007, 24(5): 839-843. doi: 10.3969/j.issn.1004-8138.2007.05.021
[9]	吴蓉, 李燕, 朱顺官, 等.等离子体电子温度的发射光谱法诊断[J].光谱学与光谱分析, 2008, 28(4): 731-735. doi: 10.3964/j.issn.1000-0593.2008.04.003 Wu Rong, Li Yan, Zhu Shun-guan, et al. Emission spectroscopy diagnostics of plasma electron temperature[J]. Spectroscopy and Spectral Analysis, 2008, 28(4): 731-735. doi: 10.3964/j.issn.1000-0593.2008.04.003
[10]	王中辉, 蒋力培, 齐铂金, 等.发展中的电弧等离子体温度场诊断技术[J].材料科学与工艺, 2007, 15(5): 654-657. doi: 10.3969/j.issn.1005-0299.2007.05.015 Wang Zhong-hui, Jiang Li-pei, Qi Bo-jin, et al. Developing diagnostics of the arc plasma temperature field[J]. Materials Science & Technology, 2007, 15(5): 654-657. doi: 10.3969/j.issn.1005-0299.2007.05.015
[11]	沈华, 陈磊, 朱日宏, 等.等离子体激发和辐射温度瞬态光谱测试方法[J].光学学报, 2009, 29(8): 2216-2220. http://d.wanfangdata.com.cn/Conference_7301660.aspx Shen Hua, Chen Lei, Zhu Ri-hong, et al. Spectroscopic diagnostication of transient excitation and radiation temperature of plasma[J]. Acta Optica Sinica, 2009, 29(8): 2216-2220. http://d.wanfangdata.com.cn/Conference_7301660.aspx
[12]	李倩, 徐送宁, 宁日波.用发射光谱法测量电弧等离子体的激发温度[J].沈阳理工大学学报, 2011, 30(1): 45-48, 89. doi: 10.3969/j.issn.1003-1251.2011.01.012 Li Qian, Xu Song-ning, Ning Ri-bo. Measurement of the arc plasma excitation temperature by emission spectroscopy method[J]. Journal of Shenyang Ligong University, 2011, 30(1): 45-48, 89. doi: 10.3969/j.issn.1003-1251.2011.01.012
[13]	苏茂根, 陈冠英, 张树东, 等.空气中激光烧蚀Cu产生等离子体发射光谱的研究[J].原子与分子物理学报, 2005, 22(3): 472-477. doi: 10.3969/j.issn.1000-0364.2005.03.016 Su Mao-gen, Chen Guan-ying, Zhang Shu-dong, et al. The research of laser induced Cu plasma emission spectra in air[J]. Journal of Atomic and Molecular Physics, 2005, 22(3): 472-477. doi: 10.3969/j.issn.1000-0364.2005.03.016
[14]	Cho C, Choi Y W, Jiang W. Time-resolved spectroscopic investigation of an exploding Cu wire process for nanosized powder synthesis[J]. Journal of the Korean Physical Society, 2005, 47(6): 987-990. http://www.researchgate.net/publication/289265077_Time-resolved_spectroscopic_investigation_of_an_exploding_cu_wire_process_for_nanosized_powder_synthesis
[15]	Baudelet M, Willis C C C, Shah L, et al. Laser-induced breakdown spectroscopy of copper with a 2μm thulium fiber laser[J]. Optics Express, 2010, 18(8): 7905-7910. doi: 10.1364/OE.18.007905
[16]	孙秀云, 周学铁, 李燕, 等.发射光谱Boltzmann法测量毛细管放电产生的电热高密度等离子体温度之误差分析[J].光谱学与光谱分析, 2003, 23(3): 563-565. doi: 10.3321/j.issn:1000-0593.2003.03.040 Sun Xiu-yun, Zhou Xue-tie, Li Yan, et al. Error analysis of temperature measurement by Boltzmann plot in atomic emission spectroscopy for a high-density plasma produced by electrothermal capillary discharge[J]. Spectroscopy and Spectral Analysis, 2003, 23(3): 563-565. doi: 10.3321/j.issn:1000-0593.2003.03.040

Relative Articles

[1]	GONG Liangfei, ZHANG Qingming, LONG Renrong, ZHANG Kai, JU Yuanyuan. The electromagnetic radiation produced by hypervelocity impact[J]. Explosion And Shock Waves, 2021, 41(2): 021402. doi: 10.11883/bzycj-2020-0396
[2]	FU Rongyao, SUN Yaohong, XU Xuzhe, YAN Ping. Effect of hydrostatic pressure on fracture of rock subjected to plasma impact[J]. Explosion And Shock Waves, 2018, 38(5): 1051-1056. doi: 10.11883/bzycj-2017-0057
[3]	Gao Na, Zhang Yansong, Hu Yiting. Experimental study on gas explosion hazard under different temperatures and pressures[J]. Explosion And Shock Waves, 2016, 36(2): 218-223. doi: 10.11883/1001-1455(2016)02-0218-06
[4]	Zhang Shufeng, Chai Hao, Zhou Yuxin, Zhang Mingzhi, Liu Zhenfeng, Wang Tian. Experimental study for discharge effect of hypervelocity impact on solar array[J]. Explosion And Shock Waves, 2016, 36(3): 386-390. doi: 10.11883/1001-1455(2016)03-0386-05
[5]	Ni Yanjie, Xing Rongjun, Wan Gang, Jin Yong, Li Haiyuan, Yang Chunxia, Li Baoming. Porous propellant burning rate enhanced by plasma[J]. Explosion And Shock Waves, 2016, 36(4): 562-567. doi: 10.11883/1001-1455(2016)04-0562-06
[6]	Zhong Wei, Tian Zhou, Zhao Yang. Calculation of the quasi-static temperature of confined explosions in consideration of the effect of the chemical reactions with detonation products[J]. Explosion And Shock Waves, 2015, 35(6): 777-784. doi: 10.11883/1001-1455(2015)06-0777-08
[7]	Liu Yun-long, Wang Yu, Zhang A-man. Whipping responses of double cylindrical shell structures to underwater explosion based on DAA₂[J]. Explosion And Shock Waves, 2014, 34(6): 691-700. doi: 10.11883/1001-1455(2014)06-0691-10
[8]	Li Run-zhi, Huang Zi-chao, Si Rong-jun. Influence of environmental temperature on gas explosion pressure and its rise rate[J]. Explosion And Shock Waves, 2013, 33(4): 415-419. doi: 10.11883/1001-1455(2013)04-0415-05
[9]	ZHANG Bao-guo, LIN Ke-ling, TIAN Xin-li, XUE Chun-fang, LI Fu-qiang. NumericalsimulationoftemperaturefieldforAl2O3ceramics duringmicro-detonationofstrikingarcmachining[J]. Explosion And Shock Waves, 2012, 32(2): 129-135. doi: 10.11883/1001-1455(2012)02-0129-07
[10]	TANG En-ling, XIANG Sheng-hai, ZHANG Wei, LI Le-xin, YU Hui, ZHAO Xin-ying. Electromagneticcharacteristicsofexpandingplasmacloud createdbyhypervelocityimpac[J]. Explosion And Shock Waves, 2012, 32(3): 283-290. doi: 10.11883/1001-1455(2012)03-0283-08
[11]	ZHU Yi-chao, LUO Gen-xin, FANG Xiang, CHEN Yu. Electricalcharacteristicsofanelectricexplodingmetalwire[J]. Explosion And Shock Waves, 2011, 31(6): 664-668. doi: 10.11883/1001-1455(2011)06-0664-05
[12]	LI Tao, FU Hua, TAN Duo-wang, LI Qiang, LU Min. Calculationsofelectricallyexplodedmetalfoilanddrivenflyer[J]. Explosion And Shock Waves, 2010, 30(1): 70-74. doi: 10.11883/1001-1455(2010)01-0070-05
[13]	CHEN Xuan, LI Yu-long, SHI Fei-fei, ZHAO Hai-yan, MA Xiao. Influences of adherent thickness, temperature and velocity on strength of adhesively-bonded single-lap joints[J]. Explosion And Shock Waves, 2009, 29(5): 449-456. doi: 10.11883/1001-1455(2009)05-0449-08
[14]	TANG En-ling, ZHANG Qing-ming, ZHANG Jian. Electron temperature diagnosis of plasma generated by hypervelocity impact of a LY12 aluminum projectile into a LY12 aluminum target[J]. Explosion And Shock Waves, 2009, 29(3): 323-327. doi: 10.11883/1001-1455(2009)03-0323-05
[15]	SUN Yu-xin, FU Yan-shu, WANG Xiao-ping. Influences of coating materials on temperature of amorphous foils during explosive welding[J]. Explosion And Shock Waves, 2008, 28(4): 350-354. doi: 10.11883/1001-1455(2008)04-0350-05
[16]	LI Xiu-li, HUI Jun-ming. Detonation temperature of thermobaric explosives[J]. Explosion And Shock Waves, 2008, 28(5): 471-475. doi: 10.11883/1001-1455(2008)05-0471-05
[17]	WANG Xin-liang, YE Dan, GU Fan. The double fluid model of the non-equilibrium ionization zone in the detonation plasma[J]. Explosion And Shock Waves, 2008, 28(2): 131-137. doi: 10.11883/1001-1455(2008)02-0131-07
[18]	LIU Jing-jing, LIU Zong-de. Theoretical analysis of the electromagnetically accelerated plasma spraying[J]. Explosion And Shock Waves, 2008, 28(1): 23-27. doi: 10.11883/1001-1455(2008)01-0023-05
[19]	ZHONG Fang-qing, LI Shan-lin, SUN Heng-zhong, ZHOU Jian-qing, WANG Wen-xue, ZOU Zu-jun. Study on seismic coupling of underground explosion in rock[J]. Explosion And Shock Waves, 2005, 25(2): 180-182. doi: 10.11883/1001-1455(2005)02-0180-03
[20]	ZHAN Ren-rui, TAO Chun-da, HAN Lin, , HUANG Yi-ming, HAN Dun-xin. The residual stress and its influence on the fatigue strength induced by explosive autofrettage[J]. Explosion And Shock Waves, 2005, 25(3): 239-243. doi: 10.11883/1001-1455(2005)03-0239-05

Supplements(0)

Cited By

Cited by

Periodical cited type(4)

1.	Songmao Zhao，Haotian Jian，Ke Wang，Zheng Ning，Peng Zhu，Ruiqi Shen. Investigation on the exploding foil initiators ignition enhanced by explosion-electricity coupling. Defence Technology. 2024(12): 1-11 .
2.	薛创，宁成，彭先觉. 水中金属丝电爆炸动力学过程的零维模型. 爆炸与冲击. 2023(05): 150-157 . 本站查看
3.	王万军，孙秀娟，张雷，雷凡，郭菲，杨爽，付秋菠. 亚微秒内金丝电爆炸的激光探针测试及三维动力学仿真. 含能材料. 2019(06): 473-480 .
4.	张永民，姚伟博，邱爱慈，汤俊萍，王宇，呼义翔. 金属丝电爆炸现象研究综述. 高电压技术. 2019(08): 2668-2680 .