Quasi-static gas pressure generated by explosive charge blasting in a spherical explosion containment vessel

LIU Wenxiang; ZHANG Dezhi; ZHONG Fangping; CHENG Shuai; ZHANG Qingming

doi:10.11883/bzycj-2017-0056

Volume 38 Issue 5

Jul. 2018

Turn off MathJax

Article Contents

Abstract

References

Article Navigation > Explosion And Shock Waves > 2018 > 38(5): 1045-1050

LIU Wenxiang, ZHANG Dezhi, ZHONG Fangping, CHENG Shuai, ZHANG Qingming. Quasi-static gas pressure generated by explosive charge blasting in a spherical explosion containment vessel[J]. Explosion And Shock Waves, 2018, 38(5): 1045-1050. doi: 10.11883/bzycj-2017-0056

Citation:

LIU Wenxiang, ZHANG Dezhi, ZHONG Fangping, CHENG Shuai, ZHANG Qingming. Quasi-static gas pressure generated by explosive charge blasting in a spherical explosion containment vessel[J]. Explosion And Shock Waves, 2018, 38(5): 1045-1050. doi: 10.11883/bzycj-2017-0056

Citation:

LIU Wenxiang, ZHANG Dezhi, ZHONG Fangping, CHENG Shuai, ZHANG Qingming. Quasi-static gas pressure generated by explosive charge blasting in a spherical explosion containment vessel[J]. Explosion And Shock Waves, 2018, 38(5): 1045-1050. doi: 10.11883/bzycj-2017-0056

PDF( 2071 KB)

Quasi-static gas pressure generated by explosive charge blasting in a spherical explosion containment vessel

doi: 10.11883/bzycj-2017-0056

1.
State Key Laboratory of Explosion Science and Technology, Beijing Institute of Technology, Beijing 100081, China
2.
Key Laboratory of Intense Dynamic Loading and Effect, Northwest Institute of Nuclear Technology, Xi'an 710024, Shaanxi, China

Received Date: 2017-02-22
Rev Recd Date: 2017-06-30
Publish Date: 2018-09-25

Abstract

Abstract

Quasi-static pressure is important for the design of explosion containment vessels. Experiments of the spherical vessel under blast loading, in which the quasi-static pressure was measured by the pressure sensors of two different installations, i.e. flush installation and guide-hole installation, were carried out. The data obtained by the pressure sensors are consistent with each other. Based on the formula form derived theoretically, the empirical formula was obtained by fitting the data. The main results are as follows:(1) the pressure in the vessel goes into quasi-static state after the blast wave reflects back and forth three times in the vessel; (2) the quasi-static pressure in the spherical vessel is proportional to the explosion equivalent-to-vessel volume ratio, and the empirical coefficient is 1.10 MPa·m³/kg TNT.
- quasi-static pressure,
- spherical explosion containment vessel,
- explosion equivalent-to-vessel volume ratio,
- pressure sensor

FullText(HTML)

References(13)

References

[1]	BULTMAN D H. Static-stress analysis of dual-axis confinement vessel: LA-12434-MS[R]. 1992: 93.
[2]	胡八一, 刘大敏.密封结构内炸药爆炸产生的准静态气体压力研究评述[J].爆轰波与冲击波, 2001(1):11-16. http://lib.cqvip.com/qk/81668X/200001/5132138.html
[3]	郝保田.地下核爆炸及其应用[M].北京:国防工业出版社, 2002:18-88.
[4]	MARCHAND K A, COX P A, POLCYN M A. A design guide and specification for small explosive containment structures: SAND-94-2255[R]. 1994. DOI: 10.2172/10120233.
[5]	PASTRNAK J W, BAKER C F, SIMMONS L F. Measurements of a 1/4-scale model of a 60-kg explosives firing chamber: UCRL-JC-117774[R]. 1995.
[6]	CHANDLER J, FERGUSON R E, FORBES J, et al. Confined combustion of TNT explosion products in air: UCRL-JC-131748[R]. 1998.
[7]	ANDERSON C E, BAKER W E, WAUTERS D K, et al. Quasi-static pressure, duration, and impulse for explosions (eg HE) in structures[J]. International Journal of Mechanical Sciences, 1983, 25(6):455-464. doi: 10.1016/0020-7403(83)90059-0
[8]	ANTHONY J R, FOSTER P A. Explosive containment study: DE85011719[R]. 1985.
[9]	王等旺, 张德志, 李焰, 等.爆炸容器内准静态气压实验研究[J].兵工学报, 2012, 33(12):1493-1497. http://d.old.wanfangdata.com.cn/Periodical/bgxb201212014 WANG Dengwang, ZHANG Dezhi, LI Yan, et al. Experiment investigation on quasi-static pressure in explosion containment vessels[J]. Acta Armamentarii, 2012, 33(12):1493-1497. http://d.old.wanfangdata.com.cn/Periodical/bgxb201212014
[10]	林俊德.封闭空间的化爆荷载与沙墙消波[J].解放军理工大学学报(自然科学版), 2007, 8(6):559-566. http://d.old.wanfangdata.com.cn/Periodical/jfjlgdxxb200706001 LIN Junde. Chemical explosion loads in enclosed space and wave attenuation of sand wall[J]. Journal of PLA University of Science and Technology (Natural Science Edition), 2007, 8(6):559-566. http://d.old.wanfangdata.com.cn/Periodical/jfjlgdxxb200706001
[11]	钟方平.柱形容器内部爆炸流场的数值模拟[J].计算物理, 2000, 17(6):695-701. doi: 10.3969/j.issn.1001-246X.2000.06.017 ZHONG Fangping. Numerical simulation of unsteady flow within cylindrical container[J]. Chinese Journal of Computational Physics, 2000, 17(6):695-701. doi: 10.3969/j.issn.1001-246X.2000.06.017
[12]	钟巍, 田宙.等压假设下考虑化学反应动力学影响的约束爆炸准静态压力的计算[J].爆炸与冲击, 2013, 33(4):375-380. doi: 10.11883/1001-1455(2013)04-0375-06 ZHONG Wei, TIAN Zhou. Calculation of quasi-static pressures for confined explosions considering chemical reactions under isobaric assumption[J]. Explosion and Shock Waves, 2013, 33(4):375-380. DOI: 10.11883/1001-1455(2013)04-0375-06.
[13]	邱嗣鑫.压力传感器引压系统对动态测试影响的讨论[J].工业仪表与自动化装置, 1984(2):1-3. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=QK000000987503

Relative Articles

Supplements(0)

Cited By

Cited by

Periodical cited type(16)

1.	陈青华，陶彦光，梁振刚，杨佳岐. 双舱室模型内爆炸临舱压力载荷特性分析. 舰船科学技术. 2024(11): 75-79 .
2.	李营，杜志鹏，陈赶超，王诗平，侯海量，李晓彬，张攀，张伦平，孔祥韶，李海涛，郭君，姚术健，王志凯，殷彩玉. 舰艇爆炸毁伤与防护若干关键问题研究进展. 中国舰船研究. 2024(03): 3-60 .
3.	胡俊华，董奇，胡八一，任逸飞，黄广炎. 抗爆容器的内部爆炸效应和动态力学行为研究进展. 含能材料. 2024(09): 986-1008 .
4.	王昭，吴祖堂，杨军，李焰，刘文祥. 新型薄膜式压力传感器的参数设计. 爆炸与冲击. 2023(07): 174-184 . 本站查看
5.	冯蕴雯，林心怡，薛小锋，杨祥，刘佳奇. 高可靠单向爆破的民机防爆结构设计. 航空学报. 2023(18): 191-205 .
6.	刘文祥，张德志，程帅，马艳军. 爆炸容器研究进展. 现代应用物理. 2023(03): 61-69 .
7.	刘欣，顾文彬，蔡星会，王涛，刘建青，王振雄，沈慧铭. 圆柱形爆炸容器的内壁爆炸载荷. 爆炸与冲击. 2022(02): 19-30 . 本站查看
8.	刘正，聂建新，徐星，朱英中，刘攀，郭学永，闫石，张韬. 密闭空间内六硝基六氮杂异伍兹烷基复合炸药能量释放特性. 兵工学报. 2022(03): 503-512 .
9.	张鹏宙，董奇，杨沙. 爆炸载荷特征参数对无限长圆柱壳弹性动态响应的影响. 爆炸与冲击. 2021(06): 48-57 . 本站查看
10.	孙琦，董奇，杨沙，张刘成. 内爆炸准静态压力对球形容器弹塑性动态响应的影响. 含能材料. 2020(01): 25-31 .
11.	张翔，崔春生，刘双峰，刘嘉颖，崔光强. 子弹在爆炸容器内的爆燃压力测试技术研究. 中国测试. 2020(01): 39-43 .
12.	张龙，邹虹，张宝国，张继军，张东亮，孔德骞. 有限空间爆炸静态压力的温度补偿方法. 爆炸与冲击. 2020(03): 100-109 . 本站查看
13.	徐景林，顾文彬，刘建青，王振雄，陆鸣，徐博奥. 圆柱形爆炸容器内爆炸载荷的分布规律. 振动与冲击. 2020(18): 276-282 .
14.	夏彬伟，高玉刚，刘承伟，欧昌楠，彭子烨，刘浪. 缝槽水压爆破破岩载荷实验研究. 工程科学学报. 2020(09): 1130-1138 .
15.	张明明，张连生，王鑫. TNT内爆准静态压力实验和数值模拟研究. 兵器装备工程学报. 2019(05): 195-199 .
16.	孙琦，董奇，杨沙，张刘成. 内爆炸准静态压力对球形容器弹性动态响应的影响. 含能材料. 2019(08): 698-707 .