3D mesoscale modeling method and dynamic mechanical properties investigation of concrete

ZHANG Yuhang; CHEN Qingqing; ZHANG Jie; WANG Zhiyong; LI Zhiqiang; WANG Zhihua

doi:10.11883/bzycj-2018-0408

Volume 39 Issue 5

May 2019

Turn off MathJax

Article Contents

Abstract

References

Article Navigation > Explosion And Shock Waves > 2019 > 39(5): 054205

ZHANG Yuhang, CHEN Qingqing, ZHANG Jie, WANG Zhiyong, LI Zhiqiang, WANG Zhihua. 3D mesoscale modeling method and dynamic mechanical properties investigation of concrete[J]. Explosion And Shock Waves, 2019, 39(5): 054205. doi: 10.11883/bzycj-2018-0408

Citation:

ZHANG Yuhang, CHEN Qingqing, ZHANG Jie, WANG Zhiyong, LI Zhiqiang, WANG Zhihua. 3D mesoscale modeling method and dynamic mechanical properties investigation of concrete[J]. Explosion And Shock Waves, 2019, 39(5): 054205. doi: 10.11883/bzycj-2018-0408

Citation:

ZHANG Yuhang, CHEN Qingqing, ZHANG Jie, WANG Zhiyong, LI Zhiqiang, WANG Zhihua. 3D mesoscale modeling method and dynamic mechanical properties investigation of concrete[J]. Explosion And Shock Waves, 2019, 39(5): 054205. doi: 10.11883/bzycj-2018-0408

PDF( 12249 KB)

3D mesoscale modeling method and dynamic mechanical properties investigation of concrete

doi: 10.11883/bzycj-2018-0408

ZHANG Yuhang^{1, 2
,},
CHEN Qingqing^{1, 2},
ZHANG Jie^{1, 2},
WANG Zhiyong^{1, 2},
LI Zhiqiang^{1, 2},
WANG Zhihua^{1, 2
,
,}

1.
Institute of Applied Mechanics, College of Mechanical and Vehicle Engineering, Taiyuan University of Technology, Taiyuan 030024, Shanxi, China
2.
Shanxi Key Laboratory of Material Strength and Structural Impact, Taiyuan University of Technology, Taiyuan 030024, Shanxi, China

Received Date: 2018-10-26
Rev Recd Date: 2018-12-10

Available Online: 2019-04-25

Publish Date: 2019-05-01

Abstract

Abstract

According to the mechanical properties and components of concrete from the mesoscale viewpoint, a simple and high-efficiency method based on 3D-Voronoi is proposed to construct realistic meso-structure model of concrete. In this paper, 3D mesoscale numerical simulation is conducted using damaged plasticity modeling under quasi-static and dynamic load. The simulation results resemble the corresponding experimental results both in strain-stress curves and failure modes. The current method can simulate static and dynamic mechanical properties well. In addition, the proved 3D model can provide an effective approach in elucidating fundamental mechanical behavior of concrete-like materials.
- concrete,
- 3D mesoscale model,
- Voronoi tessellation,
- interfacial transitional zone,
- static mechanical property

FullText(HTML)

References(22)

References

[1]	张楚汉, 唐欣薇, 周元德, 等. 混凝土细观力学研究进展综述 [J]. 水力发电学报, 2015, 34(12): 1–18. doi: 10.11660/slfdxb.20151201 ZHANG Chuhan, TANG Xinwei, ZHOU Yuande, et al. State-of-the-art literature review on concrete meso-scale mechanics [J]. Journal of Hydroelectric Engineering, 2015, 34(12): 1–18. doi: 10.11660/slfdxb.20151201
[2]	杜修力, 金浏. 细观分析方法在混凝土物理/力学性质研究方面的应用 [J]. 水利学报, 2016, 47(3): 355–371. DU Xiuli, JIN Liu. Applications of meso-scale analysis methods on the study of the physical/mechanical properties of concrete [J]. Journal of Hydraulic Engineering, 2016, 47(3): 355–371.
[3]	WITTMANN F H, ROELFSTRA P E, SADOUKI H. Simulation and analysis of composite structures [J]. Materials Science and Engineering, 1985, 68(2): 239–248.
[4]	ZHOU X Q, HAO H. Mesoscale modelling of concrete tensile failure mechanism at high strain rates [J]. Computers and Structures, 2008, 86(21−22): 2013–2026.
[5]	ZHOU X Q, HAO H. Modelling of compressive behaviour of concrete-like materials at high strain rate [J]. International Journal of Solids and Structures, 2008, 45(17): 4648–4661.
[6]	WANG X F, YANG Z J, YATES J R, et al. Monte Carlo simulations of mesoscale fracture modelling of concrete with random aggregates and pores [J]. Construction and Building Materials, 2015, 75: 35–45.
[7]	吴成, 沈晓军, 王晓鸣, 等. 细观混凝土靶抗侵彻数值模拟及侵彻深度模型 [J]. 爆炸与冲击, 2018, 38(6): 1364–1371. DOI: 10.11833/bzycj-2017-0123. WU Cheng, SHEN Xiaojun, WANG Xiaoming, et al. Numerical simulation on anti-penetration and penetration depth model of mesoscale concrete target [J]. Explosion and Shock Waves, 2018, 38(6): 1364–1371. DOI: 10.11833/bzycj-2017-0123.
[8]	WANG X, ZHANG M, JIVKOV A P. Computational technology for analysis of 3D meso-structure effects on damage and failure of concrete [J]. International Journal of Solids and Structures, 2016, 80: 310–333.
[9]	ZHANG Z, SONG X, LIU Y, et al. Three-dimensional mesoscale modelling of concrete composites by using random walking algorithm [J]. Composites Science and Technology, 2017, 149: 235–245.
[10]	邓勇军, 陈小伟, 姚勇, 等. 基于细观混凝土模型的刚性弹体正侵彻弹道偏转分析 [J]. 爆炸与冲击, 2017, 37(3): 377–386. DOI: 10.11833/1001-1455(2017)03-0377-10. DENG Yongjun, CHEN Xiaowei, YAO Yong, et al. On ballistic trajectory of rigid projectile normal penetration based on a meso-scopic concrete [J]. Explosion and Shock Waves, 2017, 37(3): 377–386. DOI: 10.11833/1001-1455(2017)03-0377-10.
[11]	ZHANG J, WANG Z, YANG H, et al. 3D meso-scale modeling of reinforcement concrete with high volume fraction of randomly distributed aggregates [J]. Construction and Building Materials, 2018, 164: 350–361. doi: 10.1016/j.conbuildmat.2017.12.229
[12]	SHENG P, ZHANG J, JI Z. An advanced 3D modeling method for concrete-like particle-reinforced composites with high volume fraction of randomly distributed particles [J]. Composites Science and Technology, 2016, 134: 26–35.
[13]	HUANG Y, YANG Z, REN W, et al. 3D meso-scale fracture modelling and validation of concrete based on in-situ X-ray computed tomography images using damage plasticity model [J]. International Journal of Solids and Structures, 2015, 67-68: 340–352.
[14]	DU X, JIN L, MA G. Numerical simulation of dynamic tensile-failure of concrete at meso-scale [J]. International Journal of Impact Engineering, 2014, 66(4): 5–17.
[15]	张锦华, 方秦, 龚自明, 等. 基于三维细观模型的全级配混凝土静态力学性能的数值模拟 [J]. 计算力学学报, 2012, 29(6): 927–933. ZHANG Jinhua, FANG Qin, GONG Ziming, et al. Numerical simulation of static mechanical properties based on 3D mesoscale model of fully-graded concete [J]. Chinese Journal of Computational Mechanics, 2012, 29(6): 927–933.
[16]	方秦, 还毅, 张亚栋. ABAQUS混凝土损伤塑性模型的静力性能分析 [J]. 解放军理工大学学报(自然科学版), 2007, 8(3): 254–260. FANG Qin, HUAI Yi, ZHANG Yadong, et al. Investigation into static properties of damaged plasticity model for concrete in ABAQUS [J]. Journal of PLA University of Science and Technology (Natural Science Edition), 2007, 8(3): 254–260.
[17]	VAN VLIET M R A, VAN MIER J G M. Softening behaviour of concrete under uniaxial compression [C] // WITTMANN F H. Fracuture mechanics of concrete structures. Freiburg: Aedificatio Publishers, 1995: 383−396.
[18]	尚世明. 普通混凝土多轴动态性能试验研究[D]. 大连: 大连理工大学, 2013.
[19]	SFER D, CAROL I, GETTU R, et al. Study of the behavior of concrete under triaxial compression [J]. Journal of Engineering Mechanics, 2002, 128(2): 156–163.
[20]	宁建国, 商霖, 孙远翔. 混凝土材料动态性能的经验公式、强度理论与唯象本构模型 [J]. 力学进展, 2006, 36(3): 389–405. doi: 10.3321/j.issn:1000-0992.2006.03.006 NING Jianguo, SHANG Lin, SUN Yuanxiang. The developments of dynamic constitutive behavior of concrete [J]. Advance in Mechanics, 2006, 36(3): 389–405. doi: 10.3321/j.issn:1000-0992.2006.03.006
[21]	宁建国, 商霖, 孙远翔. 混凝土材料冲击特性的研究 [J]. 力学学报, 2006, 38(2): 199–208. doi: 10.3321/j.issn:0459-1879.2006.02.008 NING Jianguo, SHANG Lin, SUN Yuanxiang. Investigation on impact behavior of concrete [J]. Chinese Journal of Theoretical and Applied Mechanics, 2006, 38(2): 199–208. doi: 10.3321/j.issn:0459-1879.2006.02.008
[22]	方秦, 洪建, 张锦华, 等. 混凝土类材料SHPB实验若干问题探讨 [J]. 工程力学, 2014, 31(5): 1–14. FANG Qin, HONG Jian, ZHANG Jinhua, et al. Issues of SHPB test on concrete-like material [J]. Engineering Mechanics, 2014, 31(5): 1–14.

Relative Articles

[1]	ZHANG Xiangru, CHENG Yuehua, WU Hao. Analysis on dynamic compressive behavior of concrete based on a 3D mesoscale model[J]. Explosion And Shock Waves, 2024, 44(2): 023102. doi: 10.11883/bzycj-2022-0541
[2]	REN Huilan, RONG Yu, XU Xiangzhao. An improved material model for numerical simulation of projectile perforating concrete[J]. Explosion And Shock Waves, 2022, 42(11): 113301. doi: 10.11883/bzycj-2022-0131
[3]	DANG Faning, LI Yutao, REN Jie, ZHOU Mei. Analysis of dynamic mechanics and energy characteristics of concrete impact failure[J]. Explosion And Shock Waves, 2022, 42(8): 083202. doi: 10.11883/bzycj-2021-0444
[4]	XU Liuyun, ZHANG Yuandi. Mesoscale numerical simulation on dynamical response of concrete slabs to explosion loading[J]. Explosion And Shock Waves, 2022, 42(12): 123102. doi: 10.11883/bzycj-2022-0214
[5]	JIN Liu, HAO Huimin, ZHANG Renbo, DU Xiuli. Meso-scale simulations on dynamic splitting tensile behaviors of concrete at elevated temperatures[J]. Explosion And Shock Waves, 2020, 40(5): 053102. doi: 10.11883/bzycj-2018-0401
[6]	GUO Ruiqi, REN Huiqi, LONG Zhilin, WU Xiangyun, JIANG Xiquan. Numerical simulation on a large diameter SHTB apparatus and dynamic tensile responses of concrete based on mesoscopic models[J]. Explosion And Shock Waves, 2020, 40(9): 093101. doi: 10.11883/bzycj-2020-0015
[7]	XU Songlin, SHAN Junfang, WANG Pengfei, HU Shisheng. Penetration performance of concrete under triaxial stress[J]. Explosion And Shock Waves, 2019, 39(7): 071101. doi: 10.11883/bzycj-2019-0034
[8]	HU Hongwei, FENG Haiyun, CHEN Lang, GU Xiaohui, SONG Pu. Characteristic work capability of non-ideal explosives in concrete[J]. Explosion And Shock Waves, 2018, 38(1): 197-203. doi: 10.11883/bzycj-2016-0123
[9]	WU Cheng, SHEN Xiaojun, WANG Xiaoming, YAO Wenjin. Numerical simulation on anti-penetration and penetration depth model of mesoscale concrete target[J]. Explosion And Shock Waves, 2018, 38(6): 1364-1371. doi: 10.11883/bzycj-2017-0123
[10]	Nie Liangxue, Xu Jinyu, Liu Zhiqun, Luo Xin. Dynamic constitutive model of concrete after salt corrosion[J]. Explosion And Shock Waves, 2017, 37(4): 712-718. doi: 10.11883/1001-1455(2017)04-0712-07
[11]	Xu Songlin, Wang Pengfei, Zhao Jian, Hu Shisheng. Dynamic behavior of concrete under static triaxial loadingusing 3D-Hopkinson bar[J]. Explosion And Shock Waves, 2017, 37(2): 180-185. doi: 10.11883/1001-1455(2017)02-0180-06
[12]	Deng Yongjun, Chen Xiaowei, Yao Yong, Yang Tao. On ballistic trajectory of rigid projectile normal penetration based on a meso-scopic concrete model[J]. Explosion And Shock Waves, 2017, 37(3): 377-386. doi: 10.11883/1001-1455(2017)03-0377-10
[13]	GE Tao, LIU Bao-Rong, WANG Ming-Yang. perforation of concrete targets with finite thickness by projectiles deceleration[J]. Explosion And Shock Waves, 2010, 30(2): 159-163. doi: 10.11883/1001-1455(2010)02-0159-05
[14]	WANG Yong-Gang, WANG Li-Li. Shock wave propagation characteristics in C30 concrete under plate impact loading[J]. Explosion And Shock Waves, 2010, 30(2): 119-124. doi: 10.11883/1001-1455(2010)02-0119-06
[15]	WU Xu-tao, SUN Shan-fei, LI He-ping. Numerical simulation of SHPB tests for concrete by using HJC model[J]. Explosion And Shock Waves, 2009, 29(2): 137-142. doi: 10.11883/1001-1455(2009)02-0137-06
[16]	LIU Hai-feng, NING Jian-guo. A meso-mechanical constitutive model of concrete subjected to impact loading[J]. Explosion And Shock Waves, 2009, 29(3): 261-267. doi: 10.11883/1001-1455(2009)03-0261-07
[17]	ZHANG Lei, HU Shi-sheng, CHEN De-xing, ZHANG Shou-bao, YU Ze-qing, LIU Fei. Spall characteristics of concrete materials[J]. Explosion And Shock Waves, 2008, 28(3): 193-199. doi: 10.11883/1001-1455(2008)03-0193-07
[18]	YAN Dong-ming, LIN Gao. Experimental study on dynamic properties of concrete with one-dimensional confining pressure[J]. Explosion And Shock Waves, 2007, 27(2): 121-125. doi: 10.11883/1001-1455(2007)02-0121-05
[19]	SONG Shun-cheng, CAI Hong-nian, WANG Fu-chi. 3D-numerical simulations on impact and perforation of concrete targets by projectiles[J]. Explosion And Shock Waves, 2006, 26(1): 1-6. doi: 10.11883/1001-1455(2006)01-0001-06
[20]	ZHANG De-hai, ZHU Fu-sheng, XING Ji-bo. Application of beam-particle model to the prolem of concrete penetration[J]. Explosion And Shock Waves, 2005, 25(1): 85-89. doi: 10.11883/1001-1455(2005)01-0085-05

Supplements(0)

Cited By

Cited by

Periodical cited type(10)

1.	田亮，孟俊良，赵健，樊立龙，王宇宁，张诚至. 基于内聚力模型的混凝土断裂性能三维细观模拟. 工业建筑. 2024(09): 170-176 .
2.	姜珊，路国运，杨会伟. 侧向冲击载荷下钢管混凝土结构的动力响应及参数分析. 爆炸与冲击. 2023(11): 28-39 . 本站查看
3.	程想，曹俊鑫，王玲玲，赵银霜，孔德文. 基于细观模型的混凝土力学性能研究进展. 混凝土与水泥制品. 2022(01): 27-32+37 .
4.	徐磊，姜磊，周昌巧，任青文. 基于多重点云与分级聚合的全级配混凝土三维细观结构高效生成方法. 水利学报. 2022(02): 188-199 .
5.	吴宇航，肖映雄，徐亚飞. 基于Python-Abaqus的混凝土三维细观随机模型的建立. 计算力学学报. 2022(05): 566-573 .
6.	张杰，王志华，王志勇，树学峰. 骨料对刚性弹正侵彻混凝土过程的影响机理. 中国科学:技术科学. 2021(03): 272-280 .
7.	陈青青，张煜航，张杰，王志勇，王志华. 含孔隙混凝土二维细观建模方法研究. 应用数学和力学. 2020(02): 182-194 .
8.	方建银，李娜，党发宁，潘优，任劼. 基于破损分区理论和CT数重建混凝土数值模型. 长安大学学报(自然科学版). 2020(02): 66-73 .
9.	张超，刘占芳. 低压对变温环境下高聚物黏结炸药界面损伤的抑制. 应用数学和力学. 2020(10): 1057-1071 .
10.	于华洋，马涛，王大为，王朝辉，吕松涛，朱兴一，刘鹏飞，李峰，肖月，张久鹏，罗雪，金娇，郑健龙，侯越，徐慧宁，郭猛，蒋玮. 中国路面工程学术研究综述·2020. 中国公路学报. 2020(10): 1-66 .