PP/CF增强珊瑚砂水泥基复合材料冲击压缩力学性能研究

郑志豪; 任辉启; 龙志林; 郭瑞奇; 蔡洋; 黎智健

doi:10.11883/bzycj-2021-0297

PP/CF增强珊瑚砂水泥基复合材料冲击压缩力学性能研究

doi: 10.11883/bzycj-2021-0297

1.
湘潭大学土木工程与力学学院，湖南湘潭 411105
2.
军事科学院国防工程研究院，河南洛阳 471023

基金项目: 国家自然科学基金(51971188)；湖南省科技重大专项(2019GK1012)；湖湘高层次人才聚集工程-创新团队项目(2019RS1059)

详细信息

作者简介:
郑志豪（1998－　），男，硕士研究生，zzhxtu@163.com

通讯作者:
任辉启（1953－　），男，博士，研究员，博士生导师，huiq_ren@163.com

中图分类号: O346
计量
- 文章访问数: 330
- HTML全文浏览量: 147
- PDF下载量: 61
- 被引次数: 0
出版历程
- 收稿日期: 2021-07-09
- 修回日期: 2021-11-19
- 网络出版日期: 2022-06-10
- 刊出日期: 2022-07-25

A study on impact compression mechanical properties of PP/CF reinforced coral sand cement-based composites

1.
College of Civil Engineering and Mechanics, Xiangtan University, Xiangtan 411105, Hunan, China
2.
Institute of Defense Engineering, Military Academy of Sciences, Luoyang 471023, Henan, China

摘要

摘要: 在人工海水制备珊瑚砂水泥基复合材料中混杂加入碳纤维和聚丙烯纤维，得到4种不同纤维掺量的碳-聚丙烯混杂纤维增强珊瑚砂水泥基复合材料。采用直径100 mm的分离式Hopkinson压杆，对材料进行5种应变率下的冲击压缩试验，采用LS-DYNA进行相应的冲击压缩数值模拟。结果表明：(1) 试验应变率临界值为200 s⁻¹，当试验应变率大于200 s⁻¹时，混杂碳纤维和聚丙烯纤维所形成的纤维网络对试块的增韧效果加强；(2) 碳-聚丙烯混杂纤维增强珊瑚砂水泥基复合材料峰值应力具有明显的应变率效应，且动态增强因子对应变率的敏感程度较高；(3) 使用珊瑚砂细骨料导致试块内微裂纹和微空洞等缺陷较多，在珊瑚砂水泥基复合材料内混杂掺加碳纤维和聚丙烯纤维后，试块冲击抗压强度的提升有限，但珊瑚砂水泥基复合材料的抗冲击韧性显著提升；(4) 通过试验数据和参数调试确定了HJC模型的参数，试块峰值应力的模拟结果与试验结果的误差在5.97 %以内。
- 碳纤维 /
- 聚丙烯纤维 /
- 珊瑚砂水泥基复合材料 /
- 分离式Hopkinson压杆 /
- 冲击压缩力学性能 /
- LS-DYNA
Abstract: Four kinds of carbon-polypropylene hybrid fiber reinforced coral sand cement-based composites with different fiber content were obtained by mixing carbon fiber and polypropylene fiber into coral sand cement-based composites prepared by artificial seawater. Impact compression tests of this material under five strain rates were carried out with a 100-mm diameter split Hopkinson pressure bar. The parameters of Holmquist-Johnson-Cook model are determined by experimental data and parameter debugging. Based on Holmquist-Johnson-Cook model, LS-DYNA is used to simulate the impact compression of this material. By analyzing the failure mode, stress-strain curve and energy dissipation of the test blocks, the impact compression mechanical properties of carbon-polypropylene hybrid fiber reinforced coral sand cement-based composites are studied. The results are as follows. (1) The critical value of test strain rate is 200 s⁻¹; when the test strain rate is greater than 200 s⁻¹, the fiber network formed by hybrid carbon fiber and polypropylene fiber strengthens the toughening effect of the test block. (2) The peak stress of carbon-polypropylene hybrid fiber reinforced coral sand cement-based composites exhibits obvious strain rate effect, and the dynamic increase factor is highly sensitive to the strain rate. (3) The use of fine aggregate of coral sand results in more defects such as micro-cracks and micro-voids in the test block; after mixing carbon fiber and polypropylene fiber into the coral sand cement-based composites, the improvement of the impact compressive strength of the test block is limited, but the impact toughness of the coral sand cement-based composites is significantly enhanced. (4) LS-DYNA is used to numerically simulate the impact compression test process of hybrid carbon fiber (15.75 kg/m³) and polypropylene fiber (1.82 kg/m³), while the error between the simulation results of peak stress and the test results is within 5.97 %. The study is of great significance for the preparation of high performance coral sand cement-based composites and the emergency repair of offshore islands and reefs.
- carbon fiber /
- polypropylene fiber /
- coral sand cement-based composites /
- split Hopkinson pressure bar /
- impact compression mechanical properties /
- LS-DYNA

HTML全文

图 1 圆柱体试块模具

Figure 1. Cylindrical test block mold

下载: 全尺寸图片幻灯片

图 2 圆柱体试块

Figure 2. Cylinder test block

下载: 全尺寸图片幻灯片

图 3 材料严重剥落

Figure 3. Severe material spalling of test block

下载: 全尺寸图片幻灯片

图 4 外观较为完整

Figure 4. Complete appearance of test block

下载: 全尺寸图片幻灯片

图 5 分离式Hopkinson压杆试验装置

Figure 5. Split Hopkinson pressure bar test device

下载: 全尺寸图片幻灯片

图 6 入射波应力曲线

Figure 6. Stress curves of incident waves

下载: 全尺寸图片幻灯片

图 7 初始应变波

Figure 7. Initial strain waves

下载: 全尺寸图片幻灯片

图 8 应力平衡验证

Figure 8. Verification of stress balance

下载: 全尺寸图片幻灯片

图 9 应力-应变曲线

Figure 9. Stress-strain curves

下载: 全尺寸图片幻灯片

图 10 峰值应力与应变率的关系

Figure 10. Relations between peak stress and strain rate

下载: 全尺寸图片幻灯片

图 11 动态增强因子与应变率的关系

Figure 11. Relations between dynamic increase factor and strain rate

下载: 全尺寸图片幻灯片

图 12 入射波能量与应变率的关系

Figure 12. Relations between incident wave energy and strain rate

下载: 全尺寸图片幻灯片

图 13 耗散能量与应变率的关系

Figure 13. Relations between energy dissipation and strain rate

下载: 全尺寸图片幻灯片

图 14 耗散能量与入射波能量的关系

Figure 14. Relations between energy dissipation and incident wave energy

下载: 全尺寸图片幻灯片

图 15 SHPB有限元模型

Figure 15. A finite element model of the SHPB

下载: 全尺寸图片幻灯片

图 16 PP/CF增强珊瑚砂水泥基复合材料的应力-应变曲线

Figure 16. Stress-strain curves of the carbon-polypropylene hybrid fiber reinforced coral sand cement-based composites

下载: 全尺寸图片幻灯片

表 1 碳纤维和聚丙烯纤维的性能参数

Table 1. Properties of carbon fiber and polypropylene fiber

原材料	密度/(g·cm⁻³)	长度/mm	直径/μm	弹性模量/GPa	抗拉强度/MPa
碳纤维	1.75	12	7.0	228	3 500
聚丙烯纤维	0.91	19	32.7	4.236	469

下载: 导出CSV

表 2 PP/CF增强珊瑚砂水泥基复合材料的配比

Table 2. Proportion of carbon-polypropylene hybrid fiber reinforced coral sand cement-based composites

复合材料	w/(kg·m⁻³)							水胶比	塌落度/mm
复合材料	水泥	粉煤灰	珊瑚砂	人工海水	减水剂	碳纤维	聚丙烯纤维	水胶比	塌落度/mm
1	450	450	1 080	225	9	0	0	0.25	0
2	450	450	1 080	225	9	5.25	1.82	0.25	70
3	450	450	1 080	225	9	10.50	1.82	0.25	65
4	450	450	1 080	225	9	15.75	1.82	0.25	60

下载: 导出CSV

表 3 不同龄期试块的静态抗压强度

Table 3. Static compressive strengths of test blocks at different ages

试块	龄期/d	静态抗压强度/MPa	强度升降/%
1	7	37.64	0
1	28	40.67	0
2	7	34.80	−7.54
2	28	35.11	−13.67
3	7	39.52	4.99
3	28	42.06	3.41
4	7	47.64	26.57
4	28	48.31	18.78

下载: 导出CSV

表 4 PP/CF增强珊瑚砂水泥基复合材料的HJC模型参数

Table 4. HJC model parameters of the carbon-polypropylene hybrid fiber reinforced coral sand cement-based composites

ρ/(g·cm⁻³)	G/GPa	A	B	f_c/MPa	C	N	S_max	T/MPa	D₁
2.12	10.66	0.62	1.60	48.31	0.006 5	0.61	7	4.009	0.04

D₂	ε_f,min	p_c/MPa	μ_c	p_l/MPa	μ_l	K₁/GPa	K₂/GPa	K₃/GPa	S_f
1.0	0.01	16.10	0.001	800	0.1	85	171	208	0.002

下载: 导出CSV

表 5 数值模拟结果有效性验证

Table 5. A validation of numerical simulation results

$ \dot \varepsilon $/s⁻¹	f_c/MPa	σ_p/MPa		η_σ/%	ε_p		η_ε/%
$ \dot \varepsilon $/s⁻¹	f_c/MPa	试验	模拟	η_σ/%	试验	模拟	η_ε/%
113.03	48.31	60.12	63.71	5.97	0.0103	0.0092	10.68
157.88	48.31	72.71	73.72	1.39	0.0068	0.0073	7.35
200.39	48.31	86.76	87.34	0.67	0.0088	0.0102	15.90
222.74	48.31	98.89	104.28	5.45	0.0068	0.0069	1.47

下载: 导出CSV

参考文献(28)

[1]	岳承军, 余红发, 麻海燕, 等. 全珊瑚海水混凝土动态冲击性能试验研究 [J]. 材料导报, 2019, 33(16): 2697–2703. DOI: 10.11896/cldb.18070094. YUE C J, YU H F, MA H Y, et al. Experiment study on dynamic impact properties of coral aggregate seawater concrete [J]. Materials Reports, 2019, 33(16): 2697–2703. DOI: 10.11896/cldb.18070094.
[2]	达波, 余红发, 麻海燕, 等. 南海岛礁普通混凝土结构耐久性的调查研究 [J]. 哈尔滨工程大学学报, 2016, 37(8): 1034–1040. DOI: 10.11990/jheu.201505051. DA B, YU H F, MA H Y, et al. Investigation of durability of ordinary concrete structures in the South China Sea [J]. Journal of Harbin Engineering University, 2016, 37(8): 1034–1040. DOI: 10.11990/jheu.201505051.
[3]	达波, 余红发, 麻海燕, 等. 南海海域珊瑚混凝土结构的耐久性影响因素 [J]. 硅酸盐学报, 2016, 44(2): 253–260. DOI: 10.14062/j.issn.0454-5648.2016.02.11. DA B, YU H F, MA H Y, et al. Factors influencing durability of coral concrete structure in the South China Sea [J]. Journal of the Chinese Ceramic Society, 2016, 44(2): 253–260. DOI: 10.14062/j.issn.0454-5648.2016.02.11.
[4]	旷杜敏, 龙志林, 周益春, 等. 珊瑚礁岩土材料的物理力学性能研究综述 [J]. 湘潭大学自然科学学报, 2018, 40(5): 108–126. DOI: 10.13715/j.cnki.nsjxu.2018.05.017. KUANG D M, LONG Z L, ZHOU Y C, et al. A review of the physical and mechanical properties of coral reef [J]. Natural Science Journal of Xiangtan University, 2018, 40(5): 108–126. DOI: 10.13715/j.cnki.nsjxu.2018.05.017.
[5]	谭国金, 朱德祺, 梁春雨, 等. 桥梁用聚丙烯纤维增强水泥基复合材料的力学性能 [J]. 吉林大学学报(工学版), 2020, 50(4): 1396–1402. DOI: 10.13229/j.cnki.jdxbgxb20190914. TAN G J, ZHU D Q, LIANG C Y, et al. Mechanical properties of polypropylene fiber reinforced engineering cementitious composites for bridges [J]. Journal of Jilin University (Engineering and Technology Edition), 2020, 50(4): 1396–1402. DOI: 10.13229/j.cnki.jdxbgxb20190914.
[6]	SINGH S, SHUKLA A, BROWN R. Pullout behavior of polypropylene fibers from cementitious matrix [J]. Cement and Concrete Research, 2004, 34(10): 1919–1925. DOI: 10.1016/j.cemconres.2004.02.014.
[7]	LI V C, WANG S X, WU C. Tensile strain-hardening behavior of polyvinyl alcohol engineered cementitious composite (PVA-ECC) [J]. ACI Materials Journal, 2001, 98(6): 483–492.
[8]	严少华, 李志成, 王明洋, 等. 高强钢纤维混凝土冲击压缩特性试验研究 [J]. 爆炸与冲击, 2002, 22(3): 237–241. YAN S H, LI Z C, WANG M Y, et al. Dynamic compressive behaivour of high-strength steel fiber reiforced concrete [J]. Explosion and Shock Waves, 2002, 22(3): 237–241.
[9]	谢金, 杨伟军. 碳纤维增强水泥基复合材料的制备及热电性能研究 [J]. 功能材料, 2020, 51(4): 4148–4152,4159. DOI: 10.3969/j.issn.1001-9731.2020.04.025. XIE J, YANG W J. Preparation and thermoelectric properties of carbon fiber reinforced cement-based composite [J]. Journal of Functional Materials, 2020, 51(4): 4148–4152,4159. DOI: 10.3969/j.issn.1001-9731.2020.04.025.
[10]	LIU G J, BAI E L, XU J Y, et al. Dynamic compressive mechanical properties of carbon fiber-reinforced polymer concrete with different polymer-cement ratios at high strain rates [J]. Construction and Building Materials, 2020, 261: 119995. DOI: 10.1016/j.conbuildmat.2020.119995.
[11]	张娜, 周健, 徐名凤, 等. 玄武岩纤维高延性水泥基复合材料的动态力学性能 [J]. 爆炸与冲击, 2020, 40(5): 053101. DOI: 10.11883/bzycj-2019-0351. ZHANG N, ZHOU J, XU M F, et al. Dynamic mechanical properties of basalt fiber engineered cementitious composites [J]. Explosion and Shock Waves, 2020, 40(5): 053101. DOI: 10.11883/bzycj-2019-0351.
[12]	PAKRAVAN H R, JAMSHIDI M, LATIFI M. Study on fiber hybridization effect of engineered cementitious composites with low- and high-modulus polymeric fibers [J]. Construction and Building Materials, 2016, 112: 739–746. DOI: 10.1016/j.conbuildmat.2016.02.112.
[13]	郭瑞奇, 任辉启, 张磊, 等. 分离式大直径Hopkinson杆实验技术研究进展 [J]. 兵工学报, 2019, 40(7): 1518–1536. DOI: 10.3969/j.issn.1000-1093.2019.07.023. GUO R Q, REN H Q, ZHANG L, et al. Research progress of large-diameter split Hopkinson bar experimental technique [J]. Acta Armamentarii, 2019, 40(7): 1518–1536. DOI: 10.3969/j.issn.1000-1093.2019.07.023.
[14]	周广宇, 胡时胜. 高g值加速度发生器中的波形整形技术 [J]. 爆炸与冲击, 2013, 33(5): 479–486. DOI: 10.11883/1001-1455(2013)05-0479-08. ZHOU G Y, HU S S. Pulse-shaping techniques of high-g-value acceleration generators [J]. Explosion and Shock Waves, 2013, 33(5): 479–486. DOI: 10.11883/1001-1455(2013)05-0479-08.
[15]	果春焕, 周培俊, 陆子川, 等. 波形整形技术在Hopkinson杆实验中的应用 [J]. 爆炸与冲击, 2015, 35(6): 881–887. DOI: 10.11883/1001-1455(2015)06-0881-07. GUO C H, ZHOU P J, LU Z C, et al. Application of pulse shaping technique in Hopkinson bar experiments [J]. Explosion and Shock Waves, 2015, 35(6): 881–887. DOI: 10.11883/1001-1455(2015)06-0881-07.
[16]	SONG B, CHEN W. Dynamic stress equilibration in split Hopkinson pressure bar tests on soft materials [J]. Experimental Mechanics, 2004, 44(3): 300–312. DOI: 10.1007/BF02427897.
[17]	MA H, YUE C, YU H, et al. Experimental study and numerical simulation of impact compression mechanical properties of high strength coral aggregate seawater concrete [J]. International Journal of Impact Engineering, 2020, 137: 103466. DOI: 10.1016/j.ijimpeng.2019.103466.
[18]	张聪, 余志辉, 韩世诚, 等. 混杂纤维增强应变硬化水泥基复合材料的压缩本构关系 [J]. 复合材料学报, 2020, 37(5): 1221–1226. DOI: 10.13801/j.cnki.fhclxb.20190823.002. ZHANG C, YU Z H, HAN S C, et al. Compression constitutive relation of hybrid fiber reinforced strain hardening cementitous composites [J]. Acta Materiae Compositae Sinica, 2020, 37(5): 1221–1226. DOI: 10.13801/j.cnki.fhclxb.20190823.002.
[19]	徐世烺, 陈超, 李庆华, 等. 超高韧性水泥基复合材料动态压缩力学性能的数值模拟研究 [J]. 工程力学, 2019, 36(9): 50–59. DOI: 10.6052/j.issn.1000-4750.2018.03.0147. XU S L, CHEN C, LI Q H, et al. Numerical simulation on dynamic compressive behavior of ultra-high toughness cementitious-composites [J]. Engineering Mechanics, 2019, 36(9): 50–59. DOI: 10.6052/j.issn.1000-4750.2018.03.0147.
[20]	王道荣, 胡时胜. 骨料对混凝土材料冲击压缩行为的影响 [J]. 实验力学, 2002, 17(1): 23–27. DOI: 10.3969/j.issn.1001-4888.2002.01.004. WANG D R, HU S S. Influence of aggregate on the compression properties of concrete under impact [J]. Journal of Experimental Mechanics, 2002, 17(1): 23–27. DOI: 10.3969/j.issn.1001-4888.2002.01.004.
[21]	董凯, 任辉启, 阮文俊, 等. 珊瑚砂应变率效应研究 [J]. 爆炸与冲击, 2020, 40(9): 093102. DOI: 10.11883/bzycj-2019-0432. DONG K, REN H Q, RUAN W J, et al. Study on strain rate effect of coral sand [J]. Explosion and Shock Waves, 2020, 40(9): 093102. DOI: 10.11883/bzycj-2019-0432.
[22]	LUNDBERG B. A split Hopkinson bar study of energy absorption in dynamic rock fragmentation [J]. International Journal of Rock Mechanics and Mining Sciences & Geomechanics Abstracts, 1976, 13(6): 187–197. DOI: 10.1016/0148-9062(76)91285-7.
[23]	任根茂, 吴昊, 方秦, 等. 普通混凝土HJC本构模型参数确定 [J]. 振动与冲击, 2016, 35(18): 9–16. DOI: 10.13465/j.cnki.jvs.2016.14.002. REN G M, WU H, FANG Q, et al. Determinations of HJC constitutive model parameters for normal strength concrete [J]. Journal of Vibration and Shock, 2016, 35(18): 9–16. DOI: 10.13465/j.cnki.jvs.2016.14.002.
[24]	郭瑞奇, 任辉启, 龙志林, 等. 大直径SHTB实验装置数值模拟及混凝土细观骨料模型动态直拉研究 [J]. 爆炸与冲击, 2020, 40(9): 093101. DOI: 10.11883/bzycj-2020-0015. GUO R Q, REN H Q, LONG Z L, et al. Numerical simulation on a large diameter SHTB apparatus and dynamic tensile responses of concrete based on mesoscopic models [J]. Explosion and Shock Waves, 2020, 40(9): 093101. DOI: 10.11883/bzycj-2020-0015.
[25]	郭瑞奇, 任辉启, 张磊, 等. 基于混凝土细观骨料模型的SHPB仿真模拟研究 [J]. 振动与冲击, 2019, 38(22): 107–116. DOI: 10.13465/j.cnki.jvs.2019.22.015. GUO R Q, REN H Q, ZHANG L, et al. Simulation for SHPB tests based on a mesoscopic concrete aggregate model [J]. Journal of Vibration and Shock, 2019, 38(22): 107–116. DOI: 10.13465/j.cnki.jvs.2019.22.015.
[26]	刘海峰, 韩莉. 冲击荷载作用下混凝土动态力学性能数值模拟研究 [J]. 固体力学学报, 2015, 36(2): 145–153. DOI: 10.19636/j.cnki.cjsm42-1250/o3.2015.02.007. LIU H F, HAN L. Numerical simulation research on dynamic mechanical behaviors of concrete subjected to impact loading [J]. Chinese Journal of Solid Mechanics, 2015, 36(2): 145–153. DOI: 10.19636/j.cnki.cjsm42-1250/o3.2015.02.007.
[27]	张凤国, 李恩征. 混凝土撞击损伤模型参数的确定方法 [J]. 弹道学报, 2001, 13(4): 12–16, 23. DOI: 10.3969/j.issn.1004-499X.2001.04.003. ZHANG F G, LI E Z. A method to determine the parameters of the model for concrete impact and damage [J]. Journal of Ballistics, 2001, 13(4): 12–16, 23. DOI: 10.3969/j.issn.1004-499X.2001.04.003.
[28]	吴赛, 赵均海, 王娟, 等. 基于砼SHPB试验数值分析的HJC模型参数研究 [J]. 计算力学学报, 2015, 32(6): 789–795. DOI: 10.7511/jslx201506012. WU S, ZHAO J H, WANG J, et al. Study on parameters of HJC constitutive model based on numerical simulation of concrete SHPB test [J]. Chinese Journal of Computational Mechanics, 2015, 32(6): 789–795. DOI: 10.7511/jslx201506012.